Snow Performance Water Methanol Kit for Mahindra Roxor (DS)

Snow Performance Water Methanol Kit for Mahindra Roxor (DS)

Exergy Cp3 Conversion

Exergy Cp3 Conversion Kit for Roxor

Upgrade Your Adventure - Complete Upgrade for the Roxor

We know you want to UPGRADE YOUR ADVENTURE! 

From $0.00

To $6,574.50

In stock

SKU
roxor-bundle
Customize Upgrade Your Adventure - Complete Upgrade for the Roxor

* Required Fields

Your Customization
Upgrade Your Adventure - Complete Upgrade for the Roxor
Upgrade Your Adventure - Complete Upgrade for the Roxor

In stock

$0.00

Summary

    Tuning:

    Start here.  With the factory equipped Roxor putting just 52HP to the tires, you’ll see the most benefit from doing the tune. We offer switchable tuning that allows you to move in intervals from the factory power level up to about 120rhwp. The tuning requires that your ECM be removed and mailed to us.  We tune it and send it back with the switch and install instructions the same day.  This is a very simple process.

     

    Boost increase Valve:

    This is a simple to install product that will raise the factory boost limit from 9psi to about 16 psi.  Without this part, the stock turbo is only able to support about 80RWHP. With this part installed on the stock turbo, you can make 120rwhp with a tune. This part is not needed on the RX41 turbo as the wastegate pressure is pre-set to 25psi (more on that later).

     

    Clutch:

    The factory clutch is more-or-less up the task at ~120rwhp.  If you have stock tires and don’t murder it every chance you get you’ll probably be fine.  If, on the other hand, you have big tires, stock gears, and poor impulse control you should probably plan on replacing it.  If you’re going to upgrade the Roxor past 120rwhp this will be a mandatory mod.

     

    Turbo: 

    Now the fun starts.  We usually recommend upgrading the turbo and intercooler at the same time, but they can be done independently as well.  The RX41 is a direct drop-in replacement turbo that will dramatically improve how efficiently the engine moves air at high load without sacrificing low-end spool-up.  It sounds cool too.  The turbo upgrade moves the airflow potential of the engine from ~120HP up to about 200rwhp. It’s important to remember that you’ll need extra fuel to reach those big numbers.  With tuning, the RX41 will make about 130rwhp and it’ll do it with 200*F lower exhaust temps than the stock turbo (compared to a stock turbo at 120HP). Long story short is that your engine will be much less fatigued and less prone to long term reliability issues with the cool air and efficiency provided by the larger turbo. 

     

    Intercooler: 

    Not since 1989 has an automotive manufacturer last tried to convince the public it would be fine to run their diesel truck without an intercooler (Ram 12v Cummins).  The fact is that making power and torque in a turbo diesel engine requires high boost pressure which results in heat. The more we go down this road, the more heat we see, and the less efficient the engine's operation becomes. Our intercooler kit dramatically lowers intake temperatures and allows the engine to run happily at higher boost without danger of overheat or failure.  Adding the intercooler to a Roxor running our ‘120HP tune’ along with the RX41 lowered the EGT’s by 250*F and gained about 15HP.  On our test truck running 150HP on the RX41, simply adding the intercooler was worth over 40HP. 

     

    Methanol Injection:

    The factory fuel system limits the Roxor to about 135rwhp.  No matter how many of the previous parts we mentioned the pump simply does not have the capacity to supply any more fuel without losing pressure.  We’ve experimented with large pumps and made up to 200rwhp in the process but with that option comes considerable expense ($2500+ at the time of this writing).  Methanol injection is a less expensive way to add fuel without dramatically inflating cost.  It’s a simple kit that mounts a 2.5 gallon tank on the rear inside fender of the Roxor and runs a pump and controller to target the desired power level. 

    The kit sprays a fine mist of -30F washer fluid (methanol) directly into the intake when the controller sees boost. It does this seamlessly using a ramp program so power is predictable and linear with the throttle.  2.5 gallons of washer fluid can easily last a few fill-ups of diesel depending on how often the truck see high boost.  The addition of this kit will take a 135rwhp Roxor to 165rwhp.  Our intercooler kit has pipe plug NPT provisions for easily adding the kit, but it can be added to a non-intercooled Roxor as well.

     

     

    100 HP

    125 HP

    140 HP

    160 HP

    200 HP

    SOTF Tuning

    *

    *

    *

    *

    *

    Boost Increase Valve

    *

    *

     

     

     

    Clutch

     

    *

    *

    *

    *

    RX41 Turbo

     

     

    *

    *

    *

    RX Intercooler

     

     

    *

    *

    *

    Roxor Water Meth kit

     

     

     

    *

    *

    Exergy Roxor CP3 conversion

     

     

     

     

    *

    Prop 65WARNING: Cancer & Reproductive Harm - P65Warnings.ca.gov

     

    Write Your Own Review
    You're reviewing:Upgrade Your Adventure - Complete Upgrade for the Roxor